Replacement Car Wash Vacuum Motors for all JE Adams Vacuums that operate on 110V. 8055EM is the model number.
1.5HP, 110V/ 1 Phase, 7.6amps, based on a 2″ orifice, figures are as follows. Watts of air = 38.05, Air Flow (CFM) = 96.1, and Suction (inches of water) = 3.2.
Hours are between 800-1000.
JE Adams Car Wash Vacuum Models (with the exception of 220V units): 9235, 9225-3, 9235-3, 8704B, 9235LD, 29015, 8105, 9225, 9225-2, 9299, 8704, 9235-3LD, 8600LD, 8200, 8500LD, 8100, 8600, 8500, 9235-3DH-WALL, 8960-C, 8960, 8970, 9213LD.
Dimensions: 6.5″ in height by 5.5″ in diamete.
In the majority of cases, your equipment is operating with both heat and high pressure, as well as water. The majority of coin-operated vacuums have two motors on the top and have a lifespan of approximately 400 hours. They are easily accessible and are not prohibitively expensive. If one of them leaves, it is likely that the other will follow shortly after. The carbon brushes are a common component that needs to be addressed. These will cause the motors to fail at an earlier stage. It is recommended that the carbon brushes be inspected at least once every two months. It is a good idea to keep a few extras on hand in case you run out of supplies. The average vacuum motor lasts 45-60 days when used in a facility with 4-6 bays, so it is not uncommon to go through one every 45-60 days. When inspecting your brushes, make sure the vacuum motors are properly secured as well. It is possible that a loose motor will result in poor suction because the motor impeller will not be centered over the inlet due to the loose motor. If the pressure in your system is low, check your vacuum hoses for any potential holes.
Another possibility is that the trap door is left open, but this will necessitate the replacement of the motor. If you notice dirt around the vacuum motor, check to see if the filter bag has been torn or is not properly seated in the vacuum. Maintaining and caring for the equipment will ensure that it continues to operate and generate revenue. Before ordering a replacement motor, double-check your owner’s manual to ensure that it matches the original.
5 pounds in weigh.
It was a perfect fit and performed admirably.
